[1]毛光瑞,翟梅枝*,陈汀汀,等. 黑核桃内生真菌HJ1油脂制备生物柴油的研究[J].西北林学院学报,2014,29(06):207-211.[doi:doi:10.3969/j.issn.1001-7461.2014.06.39]
 MAO Guang-rui,ZHAI Mei-zhi*,CHEN Ting-ting,et al. Preparation of Biodiesel Produced from Microbial Oil of Black Walnut Endophyte HJ1[J].JOURNAL OF NORTHWEST FORESTRY UNIVERSITY,2014,29(06):207-211.[doi:doi:10.3969/j.issn.1001-7461.2014.06.39]
点击复制

 黑核桃内生真菌HJ1油脂制备生物柴油的研究()
分享到:

《西北林学院学报》[ISSN:1001-7461/CN:61-1202/S]

卷:
第29卷
期数:
2014年06期
页码:
207-211
栏目:
出版日期:
2014-11-30

文章信息/Info

Title:
 Preparation of Biodiesel Produced from Microbial Oil of Black Walnut Endophyte HJ1
文章编号:
1001-7461(2014)06-0207-05
作者:
 毛光瑞翟梅枝*陈汀汀史冠昭王丹
 (西北农林科技大学 林学院,陕西 杨陵 712100)
Author(s):
 MAO Guang-rui ZHAI Mei-zhi* CHEN Ting-ting SHI Guan-zhao WANG Dan
 (College of Forestry, Northwest A&F University, Yangling, Shaanxi 712100, China)
关键词:
 生物柴油微生物油脂黑核桃
Keywords:
 biodiesel microbial oil black walnut
分类号:
S713
DOI:
doi:10.3969/j.issn.1001-7461.2014.06.39
文献标志码:
A
摘要:
 对黑核桃内生真菌HJ1油脂制备生物柴油的关键技术进行研究。利用单因素试验和验证试验优化反应条件。用气相色谱-质谱联用仪(Thermo Finnigan Trace DSQ)对油脂的成分进行分析。选择甲醇为萃取剂进行降酸处理,根据植物油脂酸值测定法GB/T5530-1985进行酸值测定。采用均相碱催化酯交换法制备生物柴油,并用气相色谱内标法对所制备生物柴油的脂肪酸甲酯的组成和含量进行测定。较好的工艺条件是:醇-油摩尔比8∶1,催化剂浓度1%,反应温度60 ℃,反应时间2 h。在此条件下,甲酯含量超过98%,生物柴油得率超过66%。结果表明,HJ1油脂制备的生物柴油可以被发展为石化柴油代替品之一。
Abstract:
 The purpose of this research was to study the key technique of preparing biodiesel from endophyte HJ1 oil. Single factor experiment and verification test were adopted to evaluate the reaction conditions. The constituents of the HJ1 oil were identified by the gas chromatography-mass spectrometry (GC-MS). Methanol was used to extract extra acid in endophyte HJ1 oil, and the acid value was determined. The base-catalyzed transesterification reaction was used in the biodiesel preparation. The composition and content of fatty acid methyl esters from biodiesel prepared by HJ1 oil were measured by gas chromatography internal standard method. The results showed that under the conditions of molar ratio of methanol to oil 8:1, the concentration of catalyst 1%, the reaction temperature 60 ℃, the reaction time 2 h, the yield of biodiesel and the fatty acid methyl esters were over 66% and over 98%, respectively.

参考文献/References:

 [1]MA F, HANNA M A. Biodiesel production: a review[J]. Bioresour. Teelmol., 1999,70(1):1-15.
[2]陈俏, 李聪, 方治国,等. 利用沙生植物长柄扁桃油制备生物柴油[J]. 西北大学学报:自然科学版, 2013, 43(2):229-232.
CHENG Q, LI C, FANG Z G, et al. Preparation of biodiesel from desert Amygdalus pcdunculata pall oil[J]. Journal of Northwest University: Natural Science Edition, 2013, 43(2):229-232.(in Chinese)
[3]刘波, 孙艳, 刘永红, 等. 产油微生物油脂生物合成与代谢调控研究进展[J]. 微生物学报, 2005, 45(1):153-155.
LIU B, SUN Y, LIU Y H, et al. Progress on microbial glyceride biosynthesis and metabolic regulation in oleaginous microorganisms[J]. Acta Microbiologica Sinica, 2005, 45(1):153-155.(in Chinese)
[4]马艳玲. 微生物油脂及其生产工艺的研究进展[J]. 生物加工过程, 2006, 4(4):7-l1.
MA Y L. Microbial oils and its research advance[J]. Chinese Journal of Bioprocess Engineering,2006,4(4):7-11.(in Chinese) 
[5]翟梅枝, 陈汀汀, 李秀红,等. 黑核桃内生真菌HJ1油脂提取工艺的研究[J]. 西北林学院学报, 2010, 25(3):151-153.
ZHAI M Z, CHEN T T, LI X H, et al. Oil extraction from black walnut endophyte HJ 1[J]. Journal of Northwest Forestry University, 2010, 25(3):151-153. (in Chinese)
[6]MENG X, YANG J M, XU X, et al. Biodiesel production from oleaginous microorganisms[J]. Renewable Energy, 2008, 34 (1):1-5.
[7]刘淑君, 杨文博, 施安辉. 高产油脂酵母菌选育及摇瓶发酵条件的研究[J]. 微生物学通报, 2000, 27(2):93-97
LIU S J, YANG W B, SHI A H. Screeing of the high lipid production strains and studles on its flask culture conditions[J]. Microbiology, 2000, 27(2):93-97.(in Chinese)
[8]何东平.油脂精炼与加工工艺学[M].北京:化学工业出版社,2005:22-110
[9]杨芳霞, 李秀红, 张军华,等. 催化剂浓度对花椒油酯化产物酸值的影响[J]. 西北林学院学报, 2006, 21(6):166-169
YANG F X, LI X H, ZHANG J H, et al. Effect of catalyst concentration on the acid values of esterified Zanthoxylum bungeanum seed oil[J]. Journal of Northwest Forestry University, 2006, 21(6):166-169. (in Chinese)
[10]刘大川, 佘珠花,刘金波,等. 麻疯树籽油溶剂萃取脱酸工艺的研究[J]. 中国油脂, 2005, 30(6):26-28.
LIU D C, SHE Z H, LIU J B, et al. Deacidification of Jatropha curcas L.seed oil with solvent extraction[J]. China Oils and Fats, 2005, 30(6):26-28. (in Chinese)
[11]肖志红, 刘汝宽, 李昌珠, 等. 光皮树油溶剂萃取脱酸工艺研究[J]. 粮油加工, 2006 (11):45-50.
[12]王志华, 孙小嫂, 孙桂芳.等. 碱催化法菜籽油制备生物柴油实验研究[J]. 现代化工,2006,26(2):124-126.
WANG Z H, SUN X S, SUN G F,et al. Experimental study on preparation of biodiesel from vegetable seeds oil by KOH catalysis[J]. Modem Chemical Industry, 2006,26(2):124-126. (in Chinese)
[13]何荣. 油松籽油制备生物柴油的研究[D].西安, 陕西科技大学,2009.
[14]RAMADHAS A S, JAYARAJ S, MURALEEDHARAN C. Biodiesel production from high FFA rubber seed oil[J]. Fuel, 2005, 84(4):335-340.
[15]DMYTRYSHYN S L, DALAI A K, CHAUDHARI S T, et al. Synthesis and characterization of vegetable oil derived esters: evaluation for their diesel additive properties [J]. Resource Technology, 2004, 92(1):55-64
[16]刘传武, 杨蒸, 戴小安, 等. 植物油制备生物柴油的研究[J]. 河南化工, 2005, 22(6): 19-21.
LIU C W, YANG Z, DAI X A, et al. Study on the preparation of bio-diesel by vegetable oil[J]. Henan Chemical Industry, 2005, 22(6):19-21. (in Chinese)
[17]杨芳霞. 花椒籽油和水冬瓜籽油制备生物柴油的研究[D]. 杨陵:西北农林科技大学, 2006.
[18]ANTOLIN G, TINAUT F V, BRICENO Y, et al. Optimization of biodiesel production by sunflower oil transesterification[J]. Bioresource Technology, 2002.83(2): 111-114.
[19]HARRINGTON K. J. Chemical and physical properties of vegetable oil esters and their effect on diesel fuel performance [J] .Biomass, 1986, 9(1):1-17
[20]张学林, 唐湘华, 李俊俊,等. 低温脂肪酶酶促酯交换制备生物柴油[J]. 中国油脂,2013,38(2): 66-68.
ZHANG X L, TANG X H, LI J J, et al. Biodiesel production by low temperature lipase catalyzed transesterification[J]. China Oils and Fats, 2013,38(2):66-68. (in Chinese)
[21]刘光斌, 赵晓霞, 胡冬南, 等. 无患子油脂的提取、理化性质及其制备生物柴油的研究[J]. 中国粮油学报, 2013, 28(3):59-63.
LIU G B, ZHAO X X, HU D N, et al. Study on extraction and physiochemical properties of Sapindus mukorossi seed oil and preparation of biodiesel [J]. Journal of the Chinese Cereals and Oils Association, 2013, 28(3):59-63. (in Chinese)
[22]丁立军, 王喜明, 郝一男,等. 文冠果种仁一步法制取生物柴油的工艺优化[J]. 农业工程学报, 2013,29(6):202-208.
DING L J, WANG X M, HAO Y N, et al. Optimization of accomplishing oil extraction and biodiesel synthesis by single-step technique from Xanthoceras sorbifolia bunge kernel[J]. Transactions of the Chinese Society of Agricultural Engineering, 2013,29(6):202-208. (in Chinese)

相似文献/References:

[1]李秀红,苏印泉*,杨芳霞,等.苦楝籽油溶剂萃取降酸工艺对生物柴油质量的影响苦楝籽油溶剂萃取降酸工艺对生物柴油质量的影响[J].西北林学院学报,2009,24(02):112.
 LI Xiu hong,SU Yin quan*,YANG Fang xia,et al.Solvent Extraction to Reduce Acid Value of the Seed Oil from Melia azedarach to Make Biodiesel[J].JOURNAL OF NORTHWEST FORESTRY UNIVERSITY,2009,24(06):112.
[2]李亚藏,梁彦兰,王庆成. 铅对山梨和山荆子光合作用和叶绿素荧光特性的影响[J].西北林学院学报,2012,27(05):21.
 LI Ya-cang,LIANG Yan-lan,WANG Qing-cheng. Influence of Pb on Photosynthesis and Chlorophyll Fluorescence Characteristics in Pyrus ussuriensis and Malus baccata [J].JOURNAL OF NORTHWEST FORESTRY UNIVERSITY,2012,27(06):21.
[3]张小咏,李佳,杨艳昭,等. 基于SWAT模型的长江源区径流模拟[J].西北林学院学报,2012,27(05):38.
 ZHANG Xiao-yong,LI Jia,YANG Yan-zhao,et al. Runoff Simulation of the Catchment of the Headwaters of the Yangtze River Based on SWAT Model[J].JOURNAL OF NORTHWEST FORESTRY UNIVERSITY,2012,27(06):38.
[4]杨红旗,陈广辉,王金林. PVAc改性酚醛树脂制备铝木复合材料研究[J].西北林学院学报,2013,28(01):170.[doi:10.3969/j.issn.1001-7461.2013.01.34]
 YANG Hong-qi,CHEN Guang-hui,WANG Jin-lin. PF Adhesive Modified by PVAc for Manufacturing Technology of Decorative Fiberboard with Aluminum Foils[J].JOURNAL OF NORTHWEST FORESTRY UNIVERSITY,2013,28(06):170.[doi:10.3969/j.issn.1001-7461.2013.01.34]
[5]江涛,李秀荣,谢延军,等. 微波预处理对巨尾桉木材渗透性的影响[J].西北林学院学报,2013,28(01):174.[doi:10.3969/j.issn.1001-7461.2013.01.35]
 JIANG Tao,LI Xiu-rong,XIE Yan-jun,et al. Effects of Microwave Pretreatment on the Permeability of Eucalyptus grandis×Eucalyptus urophylla[J].JOURNAL OF NORTHWEST FORESTRY UNIVERSITY,2013,28(06):174.[doi:10.3969/j.issn.1001-7461.2013.01.35]
[6]牛晓霆,王逢瑚,曹新民. 明清家具匠师原木下料的工艺原则及措施[J].西北林学院学报,2013,28(01):178.[doi:10.3969/j.issn.1001-7461.2013.01.36]
 NIU Xiao-ting,WANG Feng-hu,CAO Xin-min. Techniques and Principles of Log Cuttings of Furniture Makers in Ming and Qing Dynasties[J].JOURNAL OF NORTHWEST FORESTRY UNIVERSITY,2013,28(06):178.[doi:10.3969/j.issn.1001-7461.2013.01.36]
[7]吕金阳,覃卓凯,舒辉,等. 银杉木材构造美学价值[J].西北林学院学报,2013,28(01):183.[doi:10.3969/j.issn.1001-7461.2013.01.37]
 LV Jin-yang,QIN Zhuo-kai,SHU Hui,et al. Esthetical Values in Wood Structure of Cathaya argyrophylla[J].JOURNAL OF NORTHWEST FORESTRY UNIVERSITY,2013,28(06):183.[doi:10.3969/j.issn.1001-7461.2013.01.37]
[8]杨艳红,张海敏,孙景荣. 基于传统文化视角的现代家具设计探析[J].西北林学院学报,2013,28(01):188.[doi:10.3969/j.issn.1001-7461.2013.01.38]
 YANG Yan-hong,ZHANG Hai-min,SUN Jing-rong. Study of Modern Furniture Design Based on Traditional Culture[J].JOURNAL OF NORTHWEST FORESTRY UNIVERSITY,2013,28(06):188.[doi:10.3969/j.issn.1001-7461.2013.01.38]
[9]黄圣游,叶喜. 新中式家具“中式”传统的界定[J].西北林学院学报,2013,28(01):192.[doi:10.3969/j.issn.1001-7461.2013.01.39]
 HUANG Sheng-You,YE Xi. Definition of Traditional Element in New Chinese Style Furniture[J].JOURNAL OF NORTHWEST FORESTRY UNIVERSITY,2013,28(06):192.[doi:10.3969/j.issn.1001-7461.2013.01.39]
[10]韩维生,赵明磊,王宏斌. 基于阈限理论的设计尺度体系[J].西北林学院学报,2013,28(01):197.[doi:10.3969/j.issn.1001-7461.2013.01.40]
 HAN Wei-sheng,ZHAO Ming-lei,WANG Hong-bin. Design Scale System Based on Threshold Theory[J].JOURNAL OF NORTHWEST FORESTRY UNIVERSITY,2013,28(06):197.[doi:10.3969/j.issn.1001-7461.2013.01.40]
[11]戚建华,姚增玉. 文冠果的生殖生物学与良种繁育研究进展[J].西北林学院学报,2012,27(03):91.
 QI Jian-hua,YAO Zeng-yu. Review on Reproductive Biology, Propagation and Breeding of Xanthoceras sorbifolia[J].JOURNAL OF NORTHWEST FORESTRY UNIVERSITY,2012,27(06):91.

备注/Memo

备注/Memo:
 收稿日期:2014-01-18修回日期:2014-05-14
基金项目:国家自然科学基金项目(31370552)。
作者简介:毛光瑞,男,在读硕士,研究方向:植物资源开发利用。E-mail: 154785632@qq.com
*通信作者:翟梅枝,女,教授,硕士生导师,研究方向:植物资源利用和植物病虫害防治。E-mail: plum-zhai@163.com
更新日期/Last Update: